Joined in 2023 
82 
63 About this deal
Depending on the make and model of your boiler, different fault codes may be displayed. If you have a Viessmann Vitodens gas boiler it is likely you will see an ‘F4’ error on the display, full details can be found in our fault code tool. For the drainage system connected internally, the diameter of the pipe must be around 22mm. For an external pipe, however, it should be around 32mm. A soakaway reduces the pressure on the burdened main drainage system since the water has some other place to go. It is also very easy and affordable to install. Outside pipes meant for sink wastes and washing machines must be insulated with waterproof and UV-resistant materials. Book a free home appointment and one of our engineers will come and make sure that pipe protection is right for you and give you a fixed-price quote
Condensate Pipe | Worcester Bosch How to Thaw a Frozen Boiler Condensate Pipe | Worcester Bosch
This guide aims to break down the complexities surrounding condensate pipes, from their construction and material to their impact on boiler efficiency. You’ll also learn about the regulations governing these pipes and how to deal with common issues like freezing during winter. Attach 90-degree PVC bend to foam insulation with electrical pipe at tip end (keep some warmer air around tip? Tip less exposed to cold air?), angled downward so it drains. If you’ve heard stories of condensate pipes freezing or being awkward to route to a drain – or even that it may have to run across the surface of a wall from the boiler to a drain – then you’re not alone. So, if any of your 22mm fittings has a metal content - such as a grab-ring - he may well have a point. Avoid excessive heat sources: While it may be tempting to use a heat gun or other high-temperature devices, it’s best to avoid excessive heat sources. Direct exposure to high temperatures can damage the pipe or other components of the boiler system.
Fixing and preventing a frozen condensate pipe
Book in your BoilerTrace Condensate installation and never worry about frozen condensing pipes ever again. I have had similar problem, but my 3/4" condensate drain (not the 2" exhaust pipe) is the problem. My unit was installed with a heat pump & the condensate drain runs on the outside of the house from the attic inside of a large piece of downspout w/ the Freon lines. I have considered heat tape, but the manufacturers say that it is not to be used on drain lines & could overheat the plastic pipe.
BoilerTrace Trace Heating Boiler Condensate Frost Protection
The reason not to use anything other than what is stated by the manufacturers and building regulations. I believe that is of PVC material. The 3-5ph acidity of water produced from combustion is likely untested and therefore not approved. Building regulations Doc H gives the only approved code of practice. If a condensate pipe is running under a floor to connect to a drain, there are still potential issues. For instance, the pipe must be clipped or supported, so it will not sag with the weight of the water within. It must also have a good fall to the drain, otherwise water will lie in the pipe and be susceptible to freezing. Essentially, this system recaptures heat that would ordinarily have disappeared up the flue and out into the world, and instead uses that heat in the water heating process. This condensing process sees the gasses from the flue undergo a substantial temperature decrease of somewhere in the region of 80 , which causes condensation to form, and that condensation needs to go somewhere.
How to safely thaw a frozen condensate pipe
The Viessmann Vitodens 050 is an excellent example of a modern condensing boiler. What Are Condensing Boilers? If you're a regular Superdrug shopper, you can now earn more freebies and discounts under its Health & Beautycard loyalty scheme, as the retailer has launched new 'VIP Rewards' as part of it.
Condensate Pipe Insulation Condensate Pipe Insulation
If it is broken, however you will need to replace your condensate pipe to stop leaks and other further problems arising. Signs of a frozen condensate pipe While their name is somewhat self-explanatory, Soakaways offer an excellent alternative if you don’t have an external drain for the condensate pipe. The basic purpose is to control the release of condensate water waste safely into the ground. It catches this water waste and through the use of limescale chippings, is able to neutralise the acidic content of the escaping water.A condensate pipe is designed to release water once the volume hits a certain threshold. Usually being released in 300ml increments (often the reason you may hear water transportation through the pipes when your boiler is operational). Increase the fall angle of the condensate pipe. This will help to improve the flow and reduce the likelihood of internal freezing. Not always the case im afraid, in fact thre are some schools of thought that suggest larger pipe is worse for freezing as it has a bigger surface area, ive had 36mm waste freezing, Best option is always to pipe internally, but if this is not possible trace heater and waterproof lagging are a must,
Great Deal 
New Comment